+234 813 0686 500
+234 809 3423 853
info@grossarchive.com

PRODUCTION AND ACCEPTABILITY STUDIES OF MALTED SORGHUM (SORGHUM BICOLOR) BISCUIT

  • Type:Project
  • Chapters:5
  • Pages:61
  • Format:Microsoft Word
(Others Project Topics & Materials)



TABLE OF CONTENTS

Title Page                                                                               

Approval Page                                                                       

Dedication                                                                              

Acknowledgement                                                                  

 Abstract                                                                                

Table Of Contents                                                                  

CHAPTER ONE

1.0            Introduction

1.1     Objectives of the study

 

CHAPTER TWO

2.0            Literature Review

2.1     Origin of Sorghum

2.2            Sorghum Utilization

2.2.1    Production of Malted Sorghum Flour

2.2.2    Malted of Sorghum

2.2.3    Steeping

2.2.4    Germination

2.2.5    Kilning

2.3            Method of Processing Wheat into Flour for Biscuit Making

2.3.1    Wheat Flour Production

2.3.2    Effects of Processing of Nutritional Value of wheat Flour

2.3.3    Functional Processing of Nutritional Value of Wheat Flour

2.4.0       Ginger

2.4.1       The History of Ginger

2.4.2       Ginger Cultivation

2.4.3       Spices and Other Oils

2.4.4       Ginger Processing

2.4.5       Uses of Ginger

2.4.6       Nutritional Composition

2.5.0       Biscuit

2.5.1       Definition of Biscuit

2.5.2       Classification of Biscuits

2.5.3       Hard Dough Biscuits

2.5.4       Lean Hard Dough Biscuits

2.5.5       Medium Hard Dough Biscuits

2.5.6       Puff Hard Biscuits

2.5.7       Lean Batter Biscuits

2.5.8       Highly Enriched Biscuits

2.5.9       Proximate Composition of Biscuits

 

CHAPTER THREE

3.0            Materials and Method

3.1     Sources of Raw Materials

3.2            Raw Materials for Baking

3.3            Equipment

3.4            Chemicals

3.5            Method for Processing Malted Sorghum

3.6            Biscuit Production

3.6.1    Proximate Analysis of the Prepared Biscuits

3.6.2     Protein Determination

3.6.3    Fat Determination

3.6.4    Moisture Determination

3.6.5    Total Ash Determination

3.6.6    Carbohydrate Determination

3.6.7    Sensory Evaluation of Prepared Samples

CHAPTER FOUR

4.0            Results and Discussions

4.1     Proximate Composition of the Test Biscuits

4.2            Sensory Evaluation

4.3            Discussion

 

CHAPTER FIVE

          Conclusion and Recommendation

          References

          Appendix

 

 

CHAPTER ONE

 

INTRODUCTION

Biscuit may be defined as a thin flat baked product made from flour, salt, sweetening agent fat and preservatives. They are crisps, unleavened and sometimes sweet pastry produced light by the addition – F baking powder or soda, sometimes with chocolate or fruit in put (Achukoh; 1992). Biscuit can also be defined as a baked product having not less than 8% of flour content calculated (Hannemah, 1981). Okaka, 1997 stated that biscuits are termed “cookies” in USA but the Word biscuit means a small cake like bun.

          According to Terrell, 1981 there are basically some ingredients that are used for biscuit production such as sugar, salt, milk, shortening flavour leavening. Egg improves the volume of biscuit as well as the taste and flavour. Egg and butter are also used for variety, these improves the quality of the products.

Wheat flour is a critical and principal raw material in biscuit production its. Superiority over other cereals is due to the presence of gluten which inherently imparts all  the essential qualities to their products. The absence of this simple protein in non-wheat flour makes them unsuitable as substitutes for wheat flour. Unfortunately, wheat is a temperature crop, there fore, our tropical climate does not favour its cultivation. Flour which has high gluten content are classified as a strong hard flour, and therefore produces a strong dough and thus a strong biscuit is produced (Richtea), while flour with small gluten content produces a soft I weak biscuit (Digestive) Aerating chemicals, syrups and water were further added as one of the basis ingredients for biscuit making (Achukoh; 1992). The production of biscuits involves weighing, mixing, dough formation, kneading and rolling out, machining and shaping, prickling Bakino, cooling and packaging (Okaka, 1997).

The malting potentials of sorghum grains can be utilized to produce soft dough biscuit. Germinated sorghum grains, develop alpha – amylase, carboxy peptidase, endo – beta – 1, 3 – glucanase, pentosanase, limit dextrinase and endo – protease in the grain during malting. Malting involves essentially steeping, germination and limiting cereals, seedling growth by kilning. During germination enzymes are produced for the degradation of starch and protein in the cereal grain. Malting yields higher proportions of hydrolytic enzymes such as X and B – amylases which may be either completely soluble or largely insoluble depending on the variety.

Malted sorghum and wheat flour are used in order to check the baking potential of biscuit, malts produce from sweet sorghum and related variety usually contain insoluble amylase. The insoluble substances that make aqueous extraction impossible (Amori, 1 9 8 7) – Glucosidase in sorghum malt is also highly insoluble malt solid (Barry, and Dorota 1988).

Malting causes a decrease in the density of caryposis in sorghum grain (Isola, 1992). Lower the amount of lysine from 0.25% in unmalted sorghum to 0.18% in sorghum malt (Ilori, 1989) and reduces the milling energy (Swanstoo et al, 1994).

Time and temperature of storage influence the percentage soluble amylase in sorghum grain. For example, sorghum grain stored at 12t 23oc temperature for 2 to 3 years give higher levels of soluble amylase (between 57 – 73%) while nearly harvested grain give about 25%. Lowering the temperature to 7oc reduces the level of soluble amylase in the level of soluble amylase in the grains to about 37% after 3 years (Novellie et al, 1973).

AIMS AND OBJECTIVES OF THE STUDY

To evaluate the acceptability of the biscuit made from malted sorghum and wheat flour blend and to reduce cost of production manufacturers, so as to break even and make gain.

Malted sorghum flour has blended with wheat flour in the preparation of some confectioneries will go a long way in reducing he country’s heavy reliance on imported wheat and conserve the Nation Foreign Exchange

PRODUCTION AND ACCEPTABILITY STUDIES OF MALTED SORGHUM (SORGHUM BICOLOR) BISCUIT

Share This

Details

Type Project
Department Others
Project ID OTH0061
Price ₦3,000 ($9)
Chapters 5 Chapters
No of Pages 61 Pages
Format Microsoft Word

500
Leave a comment...

    Details

    Type Project
    Department Others
    Project ID OTH0061
    Price ₦3,000 ($9)
    Chapters 5 Chapters
    No of Pages 61 Pages
    Format Microsoft Word

    Related Works

    ABSTRACT Biscuit was produced from malted sorghum (Sorghum bicolor) and wheat flour blend. Sorghum grains were sorted, steeped in water, germinated and kilned. Four samples of biscuit were produced using sorghum and wheat in the following ratios samples A; 30: 70,... Continue Reading
    TABLE OF CONTENTS Title Page                                                                                Approval Page                                                                       ... Continue Reading
    ABSTRACT Biscuit was produced from malted sorghum (Sorghum bicolor) and wheat flour blend. Sorghum grains were sorted, steeped in water, germinated and kilned. Four samples of biscuit were produced using sorghum and wheat in the following ratios samples A; 30: 70,... Continue Reading
    ABSTRACT Starch was extracted from two varieties of sorghum bicolor grains (white and red varieties) steeped for 6, 8 and 12 hours by wet milling method, the starch samples were analysed for yield, functional... Continue Reading
    ABSTRACT Starch was extracted from two varieties of sorghum bicolor grains (white and red varieties) steeped for 6, 8 and 12 hours by wet milling method, the starch samples were analysed for yield, functional... Continue Reading
    (SORGHUM BICOLOR, WHITE VARIETY AND RED VARIETY) ABSTRACT Starch was extracted from two varieties of sorghum bicolor grains (white and red varieties) steeped for 6, 8 and 12 hours by wet milling method, the starch samples were analysed for yield, functional... Continue Reading
    CHAPTER ONE INTRODUCTION Beer is an alcoholic beverage obtained from fermented cereals  such as barky, sorghum  and maize grains. Barkey is a well know cereals for beer production due to some great advantage it has over other cereals but because of economic reasons other cereals like sorghum as many also in... Continue Reading
    ABSTRACT This research work was on maize (Zea may) abject in sorghum vulgare) beer brewing the sorghum was malted and milled. Malting was achieved by sleeping the grains in water at 280c for 48 germination of the grain was allowed for 72 hrs and kilmed in air oven at 550c for 48 hrs. maize as an adjuct was in... Continue Reading
      ABSTRACT This study evaluated “the effects of processing methods on the physico-chemical properties of sweet potato and sorghum flour”. Sweet potato (Ipomoea batatas) is an important food crop in the tropical and sub-tropical countries and belongs to the family convolvulaceae. Sweet potatoes are rich in dietary fiber, minerals, vitamins,... Continue Reading
    ABSTRACT Complementary foods were formulated using sorghum, African yam bean and crayfish. The nutrient composition, functional properties and organoleptic attributes of the formulated complementary foods were investigated. The different flours were combined in the ratios of; 70:20:5, 80:15:5, 75:20:5, of sorghum, African yam bean and crayfish... Continue Reading